zafira tourer 2.0 cdti 2017 won't start any ideas ?

[jonnyslee]

Hi my zafira 2.0 cdti won't start at all

It cut out and wont start at all ? There was like a pinging noise when it stoppped

tried jump starting it , still won't start

EGR valve was gunked up , so were pipes, cleaned all those out

The RPM's go up when i have an ODB2 scanner plugged into it 

The fuel pressure changes on the scanner when trying to start car, the EGR valve values change on scanner

I did have some error codes below if that helps ?

 

It has the B20DTH   170 bhp engine,  was last serviced in march, new oil, oil filter, fuel filter , air filter

 

was running ok , with slight knocking noise on tick over, but no error codes before it cut out

 

P0113 Iintake air temperature sensor (confirmed)

 

P0403 Exhaust gas recirculation (EGR) circuit malfunction (pending)

Exhaust Gas Recirculation (EGR) Control circuit open

 

P0406 Exhaust gas recirculation (EGR) valve position sensor A - high input (pending)

 

 

I charged battery over night, cleared codes and they did not come back

 

Its trying to start, but eventually flattens battery after trying for a while

 

any help at all, or advice would be appreciated 

 

jonathan

 

 

 

 

 

 

[FRONTERATECH]

disconnect the maf and see if it starts P0113 refers to the MAF as sensor in it. The next thing would be leak off pipes and diesel check no leaks. Take cover off the engine look for wet leak off pipes or signs of diesel

Edited July 30 by FRONTERATECH

[jonnyslee]

tried those solution, still won't start, thanks for advice though

 

any other ideas , attached is a video of the cat trying to start

 

tried those solutions, still won't start here is a video attached if that helps ?

 

any advice would be appreciated

[FRONTERATECH]

worth checking diesel pump are you sure no airlock in fuel system take off the filler cap make sure no sign of vac lock hissing when removing after that with all diesels it is down to pipes as no fault codes could be blocked filter or bad diesel